Hi all
As some of you may know since may this year the raptor has been running badly. I am now at my wits end with it and its crunch time. Its been to my mechanic who owns a TL1000S and is a top bloke, but he is stumpt too.
The symptoms are: from cold start up till aprox 84 degrees it kangaroos and goes down intimitantly on one cylinder unless you keep the revs above 4k. After 84 degrees it seems to run ok unless the temp drops again.
So far we have tried: new thermostat, engine strip down and checked over, all was fine and complete service. My mechanic took it to have a diagnostics test and was told it needed remapping as it was all over the shot. So that was done a week ago he found a dodgy wire on the power commander and a slight leak from one of the cans but mended them and so say set up the bike as it should be.
Well you guessed it no change.....ARGHHHHHHHHHHHHHHHHHH!
Any ideas what it could be? I know its hard without seeing/hearing it but i'd really appreciate your thoughts.
I'm fast running out of time patience and money but would so love to get him running properly again!
Help! with a diagnosis needed.
- snapdragon
- Moderator
- Posts: 3245
- Joined: 21 years ago
- Location: Wiltshire
misfiring Raptor
It's not the water in the petrol tank problem again is it ? They seem prone to it, might be worth draining your tank even if just to eliminate it...
- snapdragon
- Moderator
- Posts: 3245
- Joined: 21 years ago
- Location: Wiltshire
I'll ask raptordoc when I get a chance (or at least when he answer's his phone)
It might also be worth your while asking :-
Two Wheel Technics
Telephone: 01202 814614
Three Legged Cross, Wimborne, Dorset, BH21 6SZ
or
Baines Racing
Service & Technical 01327 858510
Parts 01327 858885
Silverstone Circuit, Northants, NN12 8GX
It might also be worth your while asking :-
Two Wheel Technics
Telephone: 01202 814614
Three Legged Cross, Wimborne, Dorset, BH21 6SZ
or
Baines Racing
Service & Technical 01327 858510
Parts 01327 858885
Silverstone Circuit, Northants, NN12 8GX
SnappY
~~X~X~{:>
~~X~X~{:>